Proper animal restraint is important when giving injections; techniques will vary depending on species and size. The animal should be prevented from making any sudden movements.

This morning I picked up a batch of newly hatched broiler chicks from our post office. As I transferred them into their brooder, dunking each beak to be sure they got a good drink, I appreciated the fact they had already received their Marek’s Disease vaccine at the hatchery.

Marek’s vaccine is typically administered as a subcutaneous injection. I’m certain I would have more needles stuck in my fingers than in the chicks if I tried to vaccinate the wiggly little guys myself.

Giving injections is a standard procedure in livestock management that comes with some risk. The Upper Midwest Agricultural Safety and Health Center – UMASH, located at the University of Minnesota, reports that more than 80 percent of livestock workers have accidentally stuck themselves with a syringe when giving routine injections.

Vaccines are the most common type of product involved in those incidents. Fortunately most needle-stick injuries are minor. Even so they may result in unpleasant effects.

Keep in mind that a needle that’s been used to inject a horse, cow, sheep or pig will carry hair, dander, skin fragments and likely fecal material. Those can contribute to a skin infection, one of the most common injuries following a needle stick.

Allergic reactions, either to the organic matter on the needle or to the product that was being injected, can also occur. If a person is allergic to the product injected, such as an antibiotic, she or he could have a severe reaction. Sometimes a needle stick can result in a deep-tissue wound severe enough that it requires medical intervention.

In rare cases needle-stick injuries can be catastrophic, resulting in major injury or death. That’s usually a result of the pharmaceutical being used. Tilmicosin – brand name Micotil –which is used to treat respiratory disease in cattle, can be extremely hazardous to humans, even in very small doses. An Iowa man died from cardiac arrest in 2016 just a few hours after an accidental injection of Micotil. The exact injection dose is unknown, but it was likely less than 5cc.

Other products to be aware of include Zylazine, a sedative that can induce a coma, and injected hormones that can cause spontaneous miscarriages in pregnant women. And live vaccines, such as Bucella abortus Strain RB51 and Johne’s disease vaccine, can cause illness in humans.

There are retractable and hinge-capped needles available, but needle-stick prevention relies heavily on good needle-handling behaviors and livestock restraint. Workers administering medications should work slowly and deliberately. Needles should not be re-capped because that exposes the capping hand to the end of the needle. Never put the syringe or a needle in a pocket, regardless of whether or not it’s capped.

After multiple uses a needle degrades and may become bent. Don’t try to straighten it. Instead dispose of the needle and start with a new one.

Jeff Bender, professor of University of Minnesota-Veterinary Public Health, said more than half of needle-stick injuries actually occur after the injection or during needle disposal. Needles should never be disposed of individually in a trash receptacle. Instead provide a sharps container. They can be purchased or simply repurpose any hard-sided plastic container that has a lid. A laundry-detergent jug works well, or a cat-litter bucket with a small opening cut in the lid. After the container is full it can be sealed and put in the regular trash.

The second component of needle stick is proper animal restraint. Techniques will obviously vary depending on the species and size. The animal should be prevented from making any sudden movements, particularly with its head or neck, because many injections are given in the back of the neck or behind the ear.

Small pigs can be restrained with a sling or snare. They can also be held firmly with one arm wrapped around the legs and the other hand grasping the snout. This requires a second person to administer the injection. Cattle can be restrained in a stanchion with a halter and rope, or in a squeeze chute with a head gate.

Be sure to use the appropriate syringe and needle for the job. Syringe selection will depend on whether the injection is intramuscular or subcutaneous.

Needle size is dependent on the size of the animal and the viscosity of the solution that will be injected. For example the Virginia Polytechnic Institute and State University-Office of the University Veterinarian recommends a half-inch 16-gauge to 18-gauge needle for a pig weighing less than 25 kilograms.

Using the correct needle for the task also reduces the chance of a broken needle, which can be catastrophic if it remains in the animal and is later present in the meat.

Appropriate vaccine and medication schedules are critical to animal health and safety. Don’t neglect human safety when administering them; take the proper precautions so no one is stuck.

Visit icash.public-health.uiowa.edu for more information.

Brandi Janssen directs Iowa’s Center for Agricultural Safety and Health at the University of Iowa-College of Public Health. Visit icash.public-health.uiowa.edu for more information.

Get local news delivered to your inbox!

Editor's note: This article is part of a series featuring Wisconsin farmer-members of dairy cooperatives. The following article features Bears…

LA FARGE, Wis. – How dairy farmers farm and manage their herds has profound effects on climate-change mitigation. Erin Silva said that’s one o…

Bovine respiratory disease accounts for more than 24 percent of pre-weaned heifer deaths and about 59 percent of weaned heifer deaths on U.S. …

Research aimed at improving pig health and advancing the understanding of beneficial viruses drew a visit Aug. 18 from a foreign minister to t…

Editor's note: This article is the next in a series featuring Wisconsin farmer-members of dairy cooperatives. The following article features J…

It’s hard to encapsulate all the fascinating things about cows but here are some lesser-known facts.

The National Milk Producers Federation, the International Dairy Foods Association and the School Nutrition Association have released a fact sh…

Proper animal restraint is important when giving injections; techniques will vary depending on species and size. The animal should be prevented from making any sudden movements.

Get up-to-the-minute news sent straight to your device.